IC697ALG445
IC697ALG445
IC697ALG445
以上為變頻器設置的基本參數，其中電動機參數欄FA-01至FA-05必須按照電機銘牌上的標示進行輸入，當輸入完電機參數后，要把F0-01設置為0；F0-02設置為0；然后把FA-00設置為11，為電機靜止自整定狀態，然后對電機進行檢測，變頻器對電機檢測完畢后將F0-01和F0-02的設置改為7和1，變頻器就將控制轉變?yōu)橥獠啃盘?hào)啟動和控制。
工頻系統的操作：
當變頻系統出現故障時，可將該系統還原到原來的工頻系統工作，切換到工頻系統后要做的工作有以下幾方面：斷掉系統總電源后，將繞線式電機的轉子接線還原，連接工頻輸出端。然后再將絞車控制臺下方的凸輪控制器觸點彈簧全部安裝還原，這時工頻系統就恢復到未改變頻裝置之前一樣，提升機操作工可繼續按照原來工頻系統操作習慣進行控制。
四、節能計算
目前國內各類礦山等提升機大都采用交流繞線式異步電動機轉子串電阻方式調速方案，使用交流接觸器改變轉子電阻來進行速度段的切換。對于繞線式電機，無論在起動?制動還是調速中，采用轉子串電阻方式均會帶來電能損耗。這種損耗隨著轉速的降低，轉差率S的增大而增大。繞線式電機的功率關系為：
式中：
上式中：若S=0.5時，電磁功率就有一半的功耗消耗在轉子的電阻上，調速系統效率非常低，只有50%左右。本例中，據測算提升機有30%的時間運行在低速段，節能率在24.5%左右，經濟效益十分顯著。
并且，原系統經常故障，主要是交流接觸器觸頭頻繁閉合和斷開，容易造成觸點及線圈的燒毀，經常維護電氣部分的接觸器、電機的碳刷與機械部分的剎車裝置等。變頻調速改造后，基本上無故障，大大地減少停工損失，產生的效益也不可小視。
Reliance Electric 701819-19AC Power Cube F.C.
RELIANCE ELECTRIC CAPACITOR 603469-YAG 600VDC NEW
RELIANCE ELECTRIC TRANSFORMER 64670-15R 6467015R NEW
Expedited shipping available
Reliance Electric 802275-41R Suppressor Resistor NEW!!
RELIANCE ELECTRIC CAPACITOR 603469-AJ 80 MFD 300VDC NEW
RELIANCE ELECTRIC SERVO MOTOR # E146578 -REBUILT-
RELIANCE ELECTRIC TRANSFORMER 64670-11R 6467011R NEW
RELIANCE ELECTRIC TRANSFORMER 64670-6R 646706R NEW
Expedited shipping available
Reliance Electric 45C15D Programmable Controller #8187
**NIB** Reliance Electric Rectifier Stack 86466-88R
Reliance Electric Power Cube 701819-19AW 70181919AW NEW
Reliance Electric 78089B 78089-B NEW Free Shipping
One-day shipping available
RELIANCE ELECTRIC 62P-240-R1 *NICE*
One-day shipping available
RELIANCE ELECTRIC 411027-32R TRANSFORMER NEW
Reliance Electric HR2000 / BLA-16-1 Brushless AC Servo
NEW RELIANCE ELECTRIC CARBON BRUSH RE44-BE
Reliance Electric 846664-R UCC1 Card 846664R New
Reliance Electric Dodge 123337 Bearing Lot of 2
**NIB** Reliance Electric Rectifier Stack 86466-87R
Dodge Reliance Electric 8020F Chain Coupling Flange NEW
RELIANCE ELECTRIC AC DRIVE 1AC2002U (1671)
Reliance Electric 0-51893-4 FCCE General Field Supply
Reliance Electric 57414-1P Modbus Interface Module
RELIANCE ELECTRIC AC DRIVE 1AC2002U
Reliance Electric S20-204P2C1000/?S20204P2C1000
One-day shipping available
Reliance Electric Resolver Input 57411-1
Reliance Electric 48267-L 9.420 OHM Resistor NEW
RELIANCE ELECTRIC RESISTOR SCALING MODULE 805403-R2
Reliance Electric 8647511R Stack Rectifier 86475-11R
Reliance Electric 0-51847-4 VLDE Voltage Level Detector
Reliance Electric CDE 311A10 Relay 311A10-115 NEW
Reliance Electric 1AC2002U AC Drive #8330
Reliance Electric MD65 1HP AC Drive 6MDDN-2P3102
Expedited shipping available
RELIANCE ELECTRIC DRIVE BOARD MODEL# 0-52803-2
One-day shipping available
RELIANCE ELECTRIC PRINTED CIRCUIT 115VAC INPUT CARD
REMANUFACTURED RELIANCE ELECTRIC DIODE 405919-43AW
One-day shipping available
Reliance Electric 0-51865-14 CLDR Drive Module
Reliance Electric IRCG DC Drive Relay Module 0-51839-8
Reliance Electric Cable # 802815-22
Expedited shipping available
Reliance Electric 0-54381 Sequence Detector Card NEW
RELIANCE ELECTRIC 57416 REMOTE I/O COMMUNICATIONS MOD
Reliance Electric 14C225 Test Meter Adapter Kit 0-57006
Reliance Electric 0-52803-2 FVCC Control Card 0528032
Reliance Electric 0-52803-2 FVCC Frequency to Voltage
New Reliance Electric Sleeve 411621-09A 41162109A
Expedited shipping available
RELIANCE ELECTRIC 0-52012 PC BOARD 052012 NEW
Reliance Electric 0-51665 DRIVE CIRCUIT Board 051665
RELIANCE ELECTRIC RE0418X CARBON BRUSH LOT OF 6 NIB
NEW, Reliance Electric HR500 Servo Drive
One-day shipping available
Reliance Electric Rack 45C913 Shark 6 Slot (5 I/O)
Reliance Electric Recitifier Stack 86474-1S NEW #23166
RELIANCE ELECTRIC CO. 7018191AB POWER CUBE
Reliance Electric RE 109081-102 RC 109081102RC
Reliance Electric UDRA Board # 80950-00
Expedited shipping available
RELIANCE ELECTRIC 419904-1BX REPLACEMENT BRUSH LOT OF 7
RELIANCE ELECTRIC CLRA MODULE 0-52824
RELIANCE ELECTRIC M3452-H9C00 SNUBBER RESISTOR NIB
RELIANCE ELECTRIC 600442-14A CAPACITOR 3000MFD NEW
Reliance Electric ES281CMB 275W Power Supply 57491
Reliance Electric AutoMate # 802802-R
Expedited shipping available
**NEW** Reliance Electric PC Board # 0-48652-30
Expedited shipping available
RELIANCE ELECTRIC 410403-51AW100 AMP THYRISTOR
One-day shipping available
NEW RELIANCE ELECTRIC BRUSH BOX OF 8 419904-1AR
RELIANCE ELECTRIC 57400-1 115VAC/DC INPUT MODULE
One-day shipping available
RELIANCE ELECTRIC 0-54349 PLC MODULE
Reliance Electric 86474-7S Thyristor Assembly
NEW RELIANCE ELECTRIC RECTIFIER STACK ASSY. 86466-11R
RELIANCE ELECTRIC 0-57010 PC BOARD 057010 NEW
NIB Reliance Electric Drive Board Relay 0-55325-60
Expedited shipping available
RELIANCE ELECTRIC TLOA MODULE 0-52806
RELIANCE ELECTRIC PRINTED CIRCUIT AUTO BUS LINK
NEW RELIANCE ELECTRIC 0-52808-5 FACTORY REBUILD
Reliance Electric Printed Circuit Extender Board USED?
NEW RELIANCE ELECTRIC RECTIFIER STACK ASSY. 86466 87R
Reliance Electric 803623-R Battery Backup Unit 803623R
Reliance Electric 0-52860 VSAA Drive Regulator 052860
Reliance Electric DVDT Interface Board 0-58706-23
Reliance Electric MD65 2HP AC Drive 6MDEN-3P0102
Expedited shipping available
RELIANCE ELECTRIC CCRA 809.44-00 CONTROL CARD
Reliance Electric 57400-1 115 V AC/DC Input Module RE
**NIB** Reliance Electric Transistor 602909-123AW
Expedited shipping available
RELIANCE ELECTRIC DFSA MODULE 0-52823
New Reliance Electric 0-51377-35 Master Connection
One-day shipping available
New Reliance Electric 0-51377-38 Test Card
One-day shipping available
Reliance Electric 0-52851 CSSA Digi Card Sequencing New
New Reliance Electric 0-54394 Base Driver Card
One-day shipping available
Reliance Electric O-51829-2 LVTC Drive Module
Reliance Electric 0-57413-1A/57C4?13A Common Memory Unit
RELIANCE ELECTRIC RESISTOR
Reliance Electric Rectifier 402421-202AW
Expedited shipping available
**NIB** Reliance Electric Transistor 402410-221AW
Expedited shipping available
Reliance Electric Cardpak Amplifier 0-49022- Module
RELIANCE ELECTRIC REMANNED PLC MODULE 0-52824
Reliance Electric 0-57413-1/57C41?3A Common Memory Unit
RELIANCE ELECTRIC REMANNED PLC MODULE 0-52876
RELIANCE ELECTRIC 0-51820-2 PLC MODULE NIB
NEW RELIANCE ELECTRIC BRUSH SET 418022-1AK SET OF 8
RELIANCE ELECTRIC 0-52002-2 RELAY CARD 0520022 NEW
NEW RELIANCE ELECTRIC SUPPRESOR 600686-3AC
RELIANCE ELECTRIC REMANNED PLC MODULE 0-54355
RELIANCE ELECTRIC 0-52860-2 VSAC PLC MODULE
NEW RELIANCE ELECTRIC SUPPRESOR 600686-3RR
RELIANCE ELECTRIC 0-52859-2 VSDC PLC MODULE
RELIANCE ELECTRIC TRANSFORMER 64670-11T 6467011T NEW
NEW RELIANCE ELECTRIC THYRISTOR 410403-4Y 7139
Toledo Scale Reliance Electric KC577140 BCD Output Mod
Expedited shipping available
RELIANCE ELECTRIC REMANNED PLC MODULE 0-52823
RELIANCE ELECTRIC CRCG REGULATOR MODULE 0-51851-6
Reliance Electric 0-51874 SSCA Module
Reliance Electric 0-51884 LSCA Module
Reliance Electric 0-52808 OLVA Overload Relay Module
Reliance Electric 2DB4010 VS Drive DYNAMIC BRAKING KIT
RELIANCE ELECTRIC SUPPRESSOR 603475-S 603475S NEW
Reliance Electric S-76118B/57410 Isolated Analog Output
Reliance Electric Transistor 602909-218AW
Expedited shipping available
Reliance Electric RE DIVA Analog Board Divider 0-52804
Reliance Electric 0-51829-2 LVTC Linear Voltage Module
Reliance Electric S20-202P3C1000/?S20202P3C1000
One-day shipping available
NEW RELIANCE ELECTRIC RELAY 69326-4R
Reliance Electric AutoMate I/O Rail 45C1A
Expedited shipping available
Reliance Electric 0-52862/052862 PCB Class WI Inverter
One-day shipping available
RELIANCE ELECTRIC 0-51818-2 PLC MODULE NIB
Reliance Electric 0-57002 Instrument Interface 057002
NEW RELIANCE ELECTRIC RELAY BASE 600434-5R
Reliance Electric 0-52860-2 VSAC Inverter 0528602
Reliance Electric 0-52862 PCB Class WI Inverter 052862
Reliance Electric 0-52869 VCDA Class WI Inverter 052869
RELIANCE ELECTRIC 405919-35AR 9048 DIODE STUDS NEW
Reliance Electric VC-90 Vector Spindle Drive Manual
RELIANCE ELECTRIC 608870-48R PC GATE COUPLING - NEW
NIB RELIANCE ELECTRIC 78090-60AC
Reliance Electric Rectifier Network Assy - MaxPak
RELIANCE ELECTRIC K-604 AUXILIARY CONTACT KIT **NIB**
Reliance Electric Transformer 411027-51S 41102751S NEW
Reliance Electric Resistor 425.09.31
Reliance Electric 0-51486-17 Relay Input 05148617
RELIANCE ELECTRIC 2SR41800 SNUBBER RESISTOR
RELIANCE ELECTRIC 0-51445 CONTROL BOARD **XLNT**
NEW RELIANCE ELECTRIC 78178-11S 7817811S DIODE ASSEMBLY
